Product ID:7007S ADDITIVES FOR TOPCOAT
MSDS Date:01/01/1995
FSC:8010
NIIN:00F008097
MSDS Number: BYHRR

DU PONT E I DE NEMOURS & CO INC AUTOMOTIVE PRODS D

BRANDYWINE BLDG 3332 1007 MARKET ST
WILMINGTON, DE 19898-5000
US

Emergency Phone: 800-441-3637/800-441-7515

Info Phone: 800-441-7515/302-2774-9395

Preparer: T R LOUER

Cage: 90227

DU PONT E I DE NEMOURS & CO FABRICATED PROD DEPT

WILMINGTON, DE 19898 US

Telephone: 800-441-3637

Cage: 90227

FORMALDEHYDE, FORMALIN (SUSPECTED HUMAN CARCINOGEN BY IARC;

CAS: 50-00-0

RTECS: LP8925000

Fraction By Weight: 4%

ACGIH TLV: 0.37 MG/CUM IC (2A)

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

MELAMINE RESIN

BUTANOL, N-BUTYL ALCOHOL, PROPYL CARBINOL, BUTYL ALCOHOL

CAS: 71-36-3

RTECS: EO1400000

OSHA PEL 100 PPM

ACGIH TLV: C 152 MG/CUM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:INHALATION: NOSE & THROAT IRRITATION.
REPEATED/PROLONGED OVEREXPOSURE TO SOLVENTS MAY LEAD TO PERMANENT
BRAIN & NERVOUS SYSTEM DAMAGE. EYES: MAY CAUSE IRRITATION &
BURNING. SKIN: MAY CAUSE IRRITATION W/DERMATITIS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:GI DISTRESS, IRRITATION, BURNING, DISCOMFORT.
SOLVENTS: EYE WATERING, HEADACHE, NAUSEA, DIZZINESS, LOSS OF
COORDINATION.

First Aid:INHALATION: REMOVE TO FRESH AIR. EYES: IMMEDIATELY FLUSH
W/PLENTY OF WATER FOR 15 MINS. SKIN: WASH W/SOAP & WATER. OBTAIN
MEDICAL ATTENTION IN ALL CASES.

Flash Point Method:CC
Flash Point:>100F
Lower Limits:0.9
Upper Limits:16
Extinguishing Media:WATER SPRAY, FOAM, CO2, DRY CHEMICAL
Fire Fighting Procedures:WEAR FULL PROTECTIVE EQUIPMENT INCLUDING SCBA.
WATER FROM FOG NOZZLES MAY BE USED TO COOL CLOSED CONTAINERS TO
PREVENT PRESSURE BUILDUP.
Unusual Fire/Explosion Hazard:WHEN HEATED ABOVE THE FLASH POINT, EMITS
FLAMMABLE VAPORS WHICH, WHEN MIXED W/AIR CAN BURN/BE EXPLOSIVE.
FINE MISTS/SPRAYS MAY BE FLAMMABLE AT TEMP

Spill Release Procedures:VENTILATE AREA. REMOVE IGNITION SOURCES.
PREVENT SKIN CONTACT & BREATHING OF VAPORS. WEAR A PROPERLY FITTED
VAPOR/PARTICULATE RESPIRATOR. CONFINE & REMOVE W/INERT ABSORBENT.

Handling and Storage Precautions:KEEP AWAY FROM HEAT, SPARKS & FLAME.
CLOSE CONTAINERS AFTER EACH USE. GROUND CONTAINERS WHEN POURING.
DON'T STORE >120F..
Other Precautions:DON'T SAND, FLAME CUT, BRAZE/WELD DRY COATING W/OUT A
NIOSH/MSHA APPROVED RESPIRATOR/APPROPRIATE VENTILATION. DON'T
BREATHE VAPORS/MIST.

Respiratory Protection:WEAR A PROPERLY FITTED VAPOR/PARTICULATE
RESPIRATOR APPROVED BY NIOSH/MSHA DURING APPLICATION & UNTIL
VAPORS/MISTS ARE EXHAUSTED. CONFINED AREAS: WEAR A
POSITIVE-PRESSURE, SUPPLIED AIR RESPIRATOR. (SE E SUPP)
Ventilation:PROVIDE SUFFICIENT VENTILATION IN VOLUME & PATTERN TO KEEP
CONTAMINANTS BELOW APPLICABLE OSHA REQUIREMENTS.
Protective Gloves:NEOPRENE
Eye Protection:SPLASH GUARDS/SIDE SHIELDS
Other Protective Equipment:NEOPRENE COVERALLS.
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING & BEFORE
EATING/SMOKING.
Supplemental Safety and Health
RESPIRATORY PROTECTION CONT'D: DON'T PERMIT ANYONE W/O PROTECTION IN
THE PAINTING AREA.

Boiling Pt:B.P. Text:169-612F
Vapor Density:>1
VOC Grams/Liter:5.
Evaporation Rate & Reference:LESS THAN ETHER
Solubility in Water:MISCIBLE
Percent Volatiles by Volume:52-100

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:HEAT, SPARKS, FLAME & OTHER IGNITION
SOURCES.
Hazardous Decomposition Products:CO, CO2, SMOKE

Waste Disposal Methods:DON'T CONTAMINATE GROUND WATER SYSTEMS.
INCINERATE ABSORBED MATERIAL IAW/FEDERAL, STATE & LOCAL
REGULATIONS. DON'T INCINERATE IN CLOSED CONTAINERS. FLAMMABLE
LIQUID UN1263.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.